Removal of Organic Matter from Biogas Slurry by Binary Co-precipitation System and Mechanism Analysis

YANG Aiai; CHEN Jianguo; WANG Xiaoli; GUO Hui and ZHANG Qi

doi:10.13870/j.cnki.stbcxb.2020.01.054

您当前的位置：

首页 >

文章列表页 >

Removal of Organic Matter from Biogas Slurry by Binary Co-precipitation System and Mechanism Analysis

更新时间：2025-03-12

- Removal of Organic Matter from Biogas Slurry by Binary Co-precipitation System and Mechanism Analysis
- Vol. 34, Issue 1, Pages: 380-384(2020)
- 作者机构：
  
  1. 中南林业科技大学生命科学与技术学院,长沙,410004
  2. 南方林业生态应用技术国家工程实验室,长沙,410004
- 作者简介：
- 基金信息：
- DOI：10.13870/j.cnki.stbcxb.2020.01.054
  CLC： X713
- Published：2020
- 稿件说明：
移动端阅览
YANG Aiai, CHEN Jianguo, WANG Xiaoli, et al. Removal of Organic Matter from Biogas Slurry by Binary Co-precipitation System and Mechanism Analysis[J]. 2020, 34(1): 380-384.
DOI：

YANG Aiai, CHEN Jianguo, WANG Xiaoli, et al. Removal of Organic Matter from Biogas Slurry by Binary Co-precipitation System and Mechanism Analysis[J]. 2020, 34(1): 380-384. DOI： 10.13870/j.cnki.stbcxb.2020.01.054.

摘要

针对猪场沼液有机质含量高，其他处理工艺周期长、成本高、难去除的问题。采用包含氧化钙水溶液和AlCl3的二元共沉淀体系去除沼液有机污染物。探究了沉淀剂配比、投加量、反应时间、沼液初始pH等因素对有机物去除效果的影响。结果表明：当共沉淀剂体积比为1：2.5、投加量为1：1（体积比）、反应时间60 min、pH为9时有机质最大去除率达到93%。通过对反应前后沉淀物XRD、FITR和SEM分析，表明共沉淀剂可与沼液中带负电有机质通过电荷吸引以及与正价金属离子的络合作用絮凝沉淀有机物。沉淀反应迅速且去除有机质较为彻底，在养殖场废水处理中具有良好的工业应用前景。

Abstract

In consideration of high organic matter content in biogas slurry of pig farm

and long cycle

high cost

and difficult to remove of other treatment processing

a binary co-precipitation system comprising an aqueous calcium oxide solution and AlCl3 was applied to remove organic pollutants of biogas slurry. The effects of precipitant ratio

dosage

reaction time

and initial pH of biogas slurry on the removal of organic matter were investigated. The results showed that the maximum removal rate of organic matter reached 93% when the co-precipitant volume ratio was 1:2.5

the dosage was 1:1 (volume ratio)

and the reaction time was 60 min at pH 9. The XRD

FITR

and SEM analysis of the precipitates before and after the reaction demonstrated that the co-precipitant could flocculate and precipitate organic matter by charge attraction with negatively charged organic matter

and complexation with normal valence metal ions in the biogas slurry. The precipitation reaction was rapid and could completely remove organic matter

and had good industrial application prospects in farm wastewater treatment.

关键词

Keywords

references

徐铭泽,孙丽英,张良,等.沼液与化肥配施对西红柿生长和土壤组分的影响[J].中国沼气,2017,35(6):75-82.

孙秀艳.第-次全国污染源普查结果发布[N/OL].(2010-02-10)[2019-06-13].http://cpc.people.com.cn/GB/64093/82429/83083/10962959. html.

中华人民共和国生态环境保护部.全国环境统计公报(2015)[R]. (2017-02-23)[2019-07-10].http://www.mee.gov.cn/gzfw_13107/hjtj/qqhjtjgb/201702/t20170223_397419.shtml.

张春,郑利兵,郁达伟,等.沼液处理与资源化利用现状与展望[J].中国沼气,2018,36(5):36-46.

郜玉环,张昌爱,董建军.沼渣沼液的肥用研究进展[J].山东农业科学,2011(6):71-75.

刘荣厚, 郝元元,叶子良,等.沼气发酵工艺参数对沼气及沼液成分影响的实验研究[J].农业工程学报, 2006, 22(S1):85-88.

粟萍,赵靓,高英杰,等.不同有机肥配施沼液对葡萄产量和品质的影响[J].新疆农业科学,2014,51(4):768-776.

杨静,徐秀银.施用沼液对生菜产量及土壤质量的影响[J].中国沼气,2013,31(6):51-54.

黄界颍,伍震威,高连芬,等.沼液对土壤质量及小白菜产量品质的影响[J].安徽农业大学学报,2013,40(5):849-854.

陈永杏,董红敏,陶秀萍,等.猪场沼液灌溉冬小麦对土壤质量的影响[J].中国农学通报,2011,27(3):154-158.

王敏锋,严正娟,陈硕,等.施用粪肥和沼液对设施菜田土壤磷素累积与迁移的影响[J].农业环境科学学报,2016,35(7):1351-1359.

郑学博,樊剑波,周静,等.沼液化肥配施对红壤旱地土壤养分和花生产量的影响[J].土壤学报,2016,53(3):675-684.

黄继川,徐培智,彭智平,等.基于稻田土壤肥力及生物学活性的沼液适宜用量研究[J].植物营养与肥料学报,2016,22(2):362-371.

郑学博,樊剑波,周静.沼液还田对旱地红壤有机质及团聚体特征的影响[J].中国农业科学,2015,48(16):3201-3210.

张无敌,尹芳,李建昌,等.沼液对土壤有机质含量和肥效的影响[J].可再生能源,2008,26(6):45-47.

陈超,阮志勇,吴进, 等.规模化沼气工程沼液综合处理与利用的研究进展[J].中国沼气,2013,31(1):25-28,43.

杨治斌,吕旭东.浙江省沼液利用现状与推进机制探讨[J].浙江农业科学,2014(11):1665-1668,1673.

隋倩雯. 氨吹脱与膜生物反应器组合工艺处理猪场厌氧消化液研究[D].北京:中国农业科学院,2014.

徐国锐,石伟.沼液高值化利用研究进展[J].科技通报,2012,28(7):165-168,181.

马金华,张万明.阳离子型聚丙烯酰胺絮凝马铃薯深加工工艺蛋白废液的研究[J].安徽农业科学,2011,39(12):7083-7084,7087.

张万明,陈开陆,黄娟,等.马铃薯深加工工艺废液化学絮凝研究[J].光谱实验室,2009,26(6):1490-1495.

李亚红,高世扬,朝志萍,等.Pitzer混合参数对HCl-KCl-H

0体系25℃时溶解度预测的影响[J]. 应用化学,2001,18(2):155-157.

Views

919

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Dynamic Changes of Nitrogen,Phosphorus and Organic Matter in Soil-Water System in the Process of Biogas Slurry Flooding Treatment

Effect of Binding Agent Removal on Aggregation of Lou Soil Nanoparticles

Preliminary Study on Variation Feature of Grassland Soil Organic Matter and Nitrogen in Western Karst Rocky Desertification Region, Guizhou Province

Dynamic Variety of Soil Nutrient Content Under Conditions of Straw Mulching and Irrigation

Effects of Different Tillage Systems on Soil Labile Organic Matter and Carbon Management Index of Purple Paddy Soil

Related Author

DENG Ou-ping

SUN Si-yang

ZHANG Feng

LU Jun

LI Song-lin

XU Chenyang

GENG Zengchao

HU Feinan

Related Institution

LI Song-lin1,LU Jun1,ZHANG Feng1,SUN Si-yang2,DENG Ou-ping3(1.College of Environmental Science and Natural Resources,Zhejiang University,Hangzhou 310029,2.Zhejiang Provincial Key Laboratory of Subtropical Soil and Plant Nutrition,3.China Ministry of Education Key Lab of Environmental Remediation and Ecological Health,)

Key Laboratory of Plant Nutrition and the Agri-environment in Northwest China, Ministry of Agriculture, Northwest A&F University, Yangling

Institute of Soil and Water Conservation, Chinese Academy of Sciences & Ministry of Water Resources, Yangling

State Key Laboratory of Soil Erosion and Dryland Farming on Loess Plateau, Northwest A&F University, Yangling

College of Natural Resources and Environment, Northwest A&F University, Yangling

⁰